Product ID:A-4308-12197 AEROSOL GLOSS ORANGE
MSDS Date:01/01/1991
FSC:8010
NIIN:01-336-3981
MSDS Number: BPPJB

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE. SO.
EL MONTE, CA 91733
US

Emergency Phone: 818-444-9274

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

XYLENE; DIMETHYL BENZENE; METHYL TOLUENE (SARA 313)(VAPOR

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 10%

OSHA PEL 100 PPM

ACGIH TLV: 150 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (SARA 313)(VAPOR PRESSURE

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 27%

OSHA PEL 200 PPM

ACGIH TLV: 300 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DIPROPYLENE GLYCOL MONOMETHYLETHER ACETATE (SARA 313)

Fraction By Weight: 1%

PROPANE BLEND (VAPOR PRESSURE 8.6 MM HG @ 68F)

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 25%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

4.64 LB/GL (556 G/L)

RTECS: 9999999VO

4.64 LB/GL (556 G/L)

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE EYE IRRITATION/BLURRED
VISION. CAN CAUSE MODERATE SKIN IRRITATION/DEFATTING OF
TISSUES/DERMATITIS. CHRONIC: MAY PRODUCE LIVER/KIDNEY
DAMAGE/PERSISTANT COUGHING/BRAIN DAMAGE/DEATH.
Effects of Overexposure:INHALE:
HEADACHE/FATIGUE/WEARY/NAUSEA/VOMIT/DIZZY/STUPER/DROWSY/DISTURBED
VISION/COUGH/UNCONSCIOUS. SKIN: IRRITATE/DEFAT/DERMATITIS. EYE:
RED/TEARING/BLURRED VISION. INGEST: BREATH SMELLS-SOLVENT/IRRI TATE
LIPS/MOUTH/GASTROINTESTINAL
IRRITATE/NAUSEA/DIARRHEA/DROWSY/UNCONSCIOUS/SHOCK/WEAK/RAPID
PULSE/COLD-PALE COMPLEXION
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER AND KIDNEY
DISORDERS.

First Aid:EYE: FLUSH W/WATER 15-30 MIN. GET MED AID. SKIN: WASH AREA
W/MILD SOAP/WATER 15 MIN. REMOVE CONTAMINTATED CLOTHES. INHALE:
MOVE TO FRESH AIR. IF BREATHING IS DIFFICULT; GIVE OXYGEN. IF
BREATHING STOPP ED; GIVE ARTIFICIAL RESPIRATION. GET MED AID.
INGEST: DO NOT INDUCE VOMITING. KEEP VICTIM WARM AND SEEK MEDICAL
ATTENTION.

Flash Point Method:TCC
Flash Point:-154F,-103C
Lower Limits:1.0
Upper Limits:11.0
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:BEWARE OF EXPLOSIONS. SELF-CONTAINED BREATHING
APPARATUS W/FULL FACEPIECE OPERATED IN PRESSURE DEMAND OR OTHER
POSITIVE PRESSURE MODES.
Unusual Fire/Explosion Hazard:HEAT CAUSES EXPLOSION OF CONTAINER DUE TO
INCREASED PRESSURE. PROPANE IS EXPLOSIVE WHEN EXPOSED TO FLAME.
ISOLATE FROM HEAT/SPARKS/ELECTRICAL EQUIP/OPEN FLAME.

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION, ABSORB
LIQUIDS IN ABSORBANT MATERIAL AND PREVENT SPREADING TO GROUND
WATER.

Handling and Storage Precautions:STORE AT ROOM TEMPERATURE AWAY FROM
HEAT SOURCES AND HAVE LIDS TIGHTLY CLOSED.
Other Precautions:PROTANE-(MAY BE NARCOTIC IN VERY HIGH CONCENTRATIONS)
OSHA TWA: 1000 PPM, IDHL: 20,000 PPM, Z-A TABLE. XYLENE-OSHA TWA:
100 PPM, ACGIH: 150 PPM. AEROSOL CONTAINER PRESSURE: 45 PSI @ 68 F;
100 PSI @ 13 0F.

Respiratory Protection:NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS
ADVISED IN ABSENCE OF ENVIRONMENTAL CONTROLS. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA RESPIRATORS UNDER SPECIFIED CONDITIONS.
ENGINEERING/ADMINISTRATIVE C ONTROLS IMPLEMENTED TO REDUCE
EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Protective Gloves:POLYVINAL/ALCOHOL COATED/POLYETHYLENE
Eye Protection:OSHA APPROVED SPLASH GOGGLES
Other Protective Equipment:PREVENT REPEATED/PROLONGED SKIN CONTACT W/GB
PROTECTIVE HANDCREAM, WEAR IMPERVIOUS CLOTHING/CHEMICAL RESISTANT
BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health

Boiling Pt:B.P. Text:-44 TO 408F
Vapor Density:Spec Gravity:0.8 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NON SOLUBLE
Appearance and Odor:VARIOUS COLORS WITH SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:TEMPERATURES ABOVE 120F
Hazardous Decomposition Products:MAY PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE

Waste Disposal Methods:DO NOT INCINERATE. DISPOSE OF IN ACCORDANCE WITH
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS. AVOID PUNCTURE OF
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.